Paula Droste - Director of IR and Treasury
John Sztykiel - President and CEO
Joe Nowicki - CFO
Joe Maxa - Dougherty & Company
Ned Borland - Hudson Securities
Mike Ruggirello - Barrington Research
Spartan Motors (SPAR) Q3 2010 Earnings Call October 28, 2010 10:00 AM ET
Good morning, and welcome to the Spartan Motors third quarter 2010 earnings conference call. All participants will be in the listen-only mode until the question-and-answer session of the conference call. This call is being recorded at the request of Spartan Motors. If anyone has any objections, you may now disconnect at this time.
I'd now like to introduce Ms. Paula Droste, Director of Investor Relations and Treasury for Spartan Motors. Ms. Droste, you may proceed.
Good morning everyone, and welcome to Spartan Motors third quarter 2010 conference call. I'm Paula Droste, Director of Investor Relations and Treasury for Spartan Motors with Lambert. And Spartan's executives with me today are John Sztykiel, President and CEO; and Joe Nowicki, Chief Financial Officer.
I assume all of you saw all of you saw the company's earnings release on the news wire and internet this morning. John and Joe would take a few minutes to discuss the results for the quarter. However, before we do it, it is my responsibility to inform you that certain predictions and projections made on today's conference call regarding Spartan Motors and its operations may be considered forward-looking statements under the Securities Laws.
As a result, I must caution you that as with any prediction or projection, there are a number of factors that could cause Spartan's results to differ materially. These risk factors are identified in our Form 10-K filed with the SEC.
With that, I would like the call over to our CEO, John Sztykiel.
Paula, thank you very much, and good morning to all of those listening on today's call and those on the internet as well. Today, we'll share our results for Q3 providing detail on the quarterly and the financials and will also provide an overview on our market's operations and strategic direction followed by a Q-&-A session.
I'll quickly cover some quick financials and then go over the markets, and then Joe Nowicki will get more into detail on the financials, and then we'll ramp it up from there leave time for questions and answers afterwards.
In the third quarter, we continued to focus our efforts on the four key areas; compelling products, growth and profitable market share, cost management and balance sheet management. Each day we have the responsibility to strategically, i.e. position the organization for the future, and operationally focus the organization on short-term results.
The good news is, we made solid progress on all fronts in the third quarter. Our financial metrics reflect our efforts to re-align costs as we continue to invest in strategic growth initiatives. However, we remain guarded in our near-term outlook given the macro economic uncertainty in some of our markets.
Now, a quick recap of this quarters financial result. Sales in the quarter increased 39.7% from last year's level driven primarily by the addition of Utilimaster in December of 2009 along with increases in Motorhome and defense sales. Excluding Utilimaster, sales in the quarter increased approximately 8% versus the same quarter of 2009.
Net income form continuing operations is up 112% form the same quarter versus a year ago at $3.5 million or $0.11 per share. As I stated in prior calls, and stated a few moments ago, the foundation of our strategic and operating initiatives remain straightforward, fairly simple, but very, very focused.
First, develop compelling products and services; second, growth in profitable market share; third, cost structure management; and fourth, balance sheet management. As you look at compelling products for market initiatives, we have three great brands in Spartan Chassis, Crimson Fire, Utilimaster and now the alliance with Isuzu.
We are committed to leveraging those strengths to compelling products and growth in profitable market share and if time goes on, we will have more good days than that. We are committed to the emergency marketplace, a marketplace of tremendous opportunity.
As illustrated at first by a completely redesigned Cab and Chassis which confirms or develops or provides new product offerings under more common architectures, i.e. increased common bill of material sets. This redesigned effort while challenging but extremely well, but also provided the 2010 emissions complying engines in the marketplace, more streamlined look, and what is nice is leaner from a manufacturing perspective for both Spartan and our respective OEM partners.
In addition, as we look at Spartan Chassis in the emergency-response marketplace, not just this year, but last year as well and even in 2008, significant engineering resources have been committed to the develop and testing, and introduction of 2010 compliant emission engines.
The offerings cover engines ranging from 340 horsepower to 600 horsepower. What's amazing is when people say, why do you have to add so many different engine offerings? There's over 35,000 fire departments in North America and each department is very, very unique as to how they look at their service. Very hilly, very flat, big city; very, very spread out and it is this customization that's focused on being very customer centric that has one of our foundations in the past and will be one of our foundations in the future as well.
In addition, there will be future or increased engine offerings as we look into the future. Not in 2010, but as we go into 2011, offering's that will be driving us to be the number one spec as we look at emergency-response chassis in the future. It is imperative that we continue to support Spartan Chassis which we will and ensure that all that we do ensures that every riding on it is a Spartan Chassis or desired to be a Spartan Chassis.
Crimson Fire's Transformer, the Legend in first response are call vehicles. All offer improved maneuverability, shorter wheelbase, increased compartmentazation, reduced price points and multi use. These re-engineered vehicles are gaining momentum in the marketplace. Orders are being placed and even in a very challenging market, continue to drive opportunity for Crimson Fire.
We also expect to gain market share in 2011 with our investment in the next generation commercial vehicle or the NGCV for short. This product launch remains on schedule. Vehicle durability, testing is in place. Customer reviews and test drive runs are also under way as well.
I will say this, the response from customers that have driven the vehicle, that have done test drives has been very, very positive. So we are moving the ball in the right direction, but we will do it right. Again, this product will not roll into the marketplace till production of Q3. And when people say why did it take so long? Well, when you have some customers making 10 million package deliveries a day, it's imperative that the vehicles operate.
And if the vehicles don't operate, packages don't get delivered and that's the pretty negative moment and does not drive long term growth in shareholder or stakeholder value. We know we've got a great product, lot of compelling features around it from improved fuel economy etcetera, but we also want to make sure that we bring in the market properly.
Our strategic alliance with Isuzu, commercial truck of America, provides growth opportunities again in 2011, but also into the future as well. A simple amazing fact is Isuzu has 300 dealers in North America. And some of you have seen our PowerPoint slide showing 50 specialty vehicle markets in North America.
And when you now add in the alliance with Isuzu, we now touch 47 of those markets, through our brands of Spartan, Crimson Fire, Utilimaster or Isuzu. Does it means it's going to be great things overnight. However, we have an opportunity which we didn't have a year ago at this time. And now we are focused strategically and operationally in taking advantage of that.
The N-series Gas is on track, and as mentioned, production will start in that in the second quarter of 2011. This commitment to compelling products and innovations will create opportunities for growth and profitable market share even in uncertain times. It's easy to say, hard to do, but we are very focused on making that happen.
Earlier in the year, we also made significant changes in our cost structure and Joe will get into that in greater detail. But the financial results reflect the hard work we've done. When you look at the drop on operating expenses from 15.8% in 2009 in Q3 to 11.9% in the same quarter of 2010 as a percentage that I'm not going to get in the map, it is very, very significant.
And again, it just gets back to our four tenets, compelling products, growth in profitable market share, cost management and balance sheet management. Each and every day we are focused on those four strategic and operational initiatives. Our focus on balance sheet management continues to move in the right direction.
I just want to compliment everybody involved in our exit from the ambulance business and Road Rescue, and how that was accomplished in such a timely manner and really in a very positive, not just for Road Rescue but for Spartan as well.
On the Motorhome side of life, and I'm going to get a little bit more into the detail into each market, again Joe is going to get into the financials, something that was very, very positive in Q3 was really just the stability in the Motorhome market. Sales are increasing by $10.5 million or nearly 94% versus Q3 of 2009, but up 3% versus Q2 of this year. This stability reflects overall industry improvements compared to last year and this year which really is good news.
A strong leading indicator of the RV industry is consumer confidence, and as all of you know, while it's stabilized, it's still not been tested. And this stability/uncertainty will likely dampen any significant market rebound and I did use the term market rebound, but what I am trying to do is provide caution to you.
Been in the business since 1985, consumer confidence is one of the biggest drivers of the RV industry and right now while it's up, it's still not where it was three years ago. And while I believe the business will move in the right direction, I don't perceive it's going to take off like a rocket ship when I look at the class A business.
On a positive side, demographics are good. 11,000 people a day turn 50. It's also good for the emergency-response industry. In addition, in RV, vacation is still the lowest cost of a family vacation.
Let's switch gears to defense and specially vehicle sales. Third quarter sales were up, strong at $8.3 million, up substantially from 2009 reflecting ILAV and SOCOM orders. Again what's interesting is, there is a good article on the Wall Street Journal today taking about some of the changes going on in the military vehicle business, but what's interesting is uncertainty actually works to our benefit.
Typically larger markets become more micro markets niche-oriented, chains and create the opportunity for smaller companies like us, and what you've seen there reflected is in these ILAV and SOCOM orders which also moved upon the right direction from an income perspective.
What's also nice, is the backlog was up to $12.5 million from $4.2 million a year ago. And so as we've said in the past, on the defense side of life, we are taking a strategic approach. The wins will probably be small but the wins will be there, and over time we will grow the number of wins.
We are also very proud to achieve ISO 9001 certification this past quarter. This is integral and very, very key for us to be a long-term player in the defense marketplace. It also honestly increases how people look at us and a number of markets because what it validates, is we're becoming a world manufacturer.
And we are aligned with Isuzu today, the world's largest diesel engine manufacturer, one of the world's largest truck manufacturer and over time some of these process achievements not just help us in a specific market but they validate the opportunity for other people to work with us in other markets.
The emergency-response market, that market continues to be very challenging, continues to soften as a result of tight fiscal in state and federal budgets. Emergency-response chassis sales were down 17% for the third quarter of 2010 compared to the same quarter of 2009.
Year-to-date sales were down about 2% versus the same period in 2009. When we look at the body side of life representing Crimson Fire and Crimson Fire Aerial, sales were down 20% for the quarter compared to the same quarter of 2009.
At Crimson Fire, the decrease was partially due to the timing of some shipments, but the reality is, it's very, very difficult from a local state and federal perspective when it comes to budgets. And this will provide changes and challenges. Vehicles will change but there are significant challenges, and as we look over the next 12 to 18 months, we expect the emergency response industry to be down. We've got some products which hopefully will grow profitable market share but as a whole, that will be a very challenging market.
As we look to the future though, the reality is there's a call for help every 1.25 seconds and another very positive sign, 54% of all fire trucks and in service today are more than 15 years old, and that is a positive which over time will drive the opportunity in the right direction.
In closing, as we look at our markets, the aftermarket parts and assemblies are year-over-year reduction in sales of 21% to approximately $20 million. This was driven in large by MMPV contracts that were concluded in 2009, but also a reduction from a scope, relative to the wars going on in Afghanistan and Iraq.
The reality is if the war is lying down, which is good news in a lot of respect, the defense side of life relative to aftermarket parts and assemblies is just not as strong as what it was a year ago.
However, on the other positive side, we had growth in emergency-response, we had growth in delivering the service and we had growth in recreation, especially vehicle when we look at the aftermarket parts and assemblies area. Because we have over 220,000 vehicles in operation today and we are focused on leveraging them.
Sales in our delivery and service segment, as I mentioned a few moments ago, increased $5.2 million or 23% in the second quarter as orders from the previous quarters were filled. While Utilimaster's backlog declined from the second quarter, we remain highly optimistic about our investment in the NGCV, the next generation vehicle, as there are significant improvements in fuel economy, the speed to enter and exit the vehicle, and again, that will be introduced in the second half of 2011.
But everything which we're seeing from the marketplace indicates that we have a product that will transform the delivery and service marketplace. It's also important to know that Utilimaster generated a profit in the third quarter of 2010 as did Crimson Fire, as did Spartan Chassis, so all three brands were on the right side of the fence and I want to give thanks to all of Spartan associates.
First, I'll cover a quick housekeeping item regarding the structured financials consistent with the counting guidelines and also the format presented in the second quarter as Road Rescue results have been classified as discontinued operations. So all the sales, cost of sales, operating expenses and other income expense from Road Rescue have been pulled out including historical expenses and put into one summarized line item.
Our third quarter results reflect the fulfillment of the commitments we made last quarter. As I mentioned in the last call, we expected a positive outlook for the second quarter of 2010, if we deliver down this quarter.
Second, we quickly exited the Road Rescue business as we announced we would do last quarter to free up resources and focus on more profitable initiatives, the sales growth on September 20. The exit also improved our balance sheet as the sale of business freed up capital and provided further liquidity.
But difficult decisions were made in the prior quarters to curtail cost in the right side of the organization in light of the current marketing conditions are paying dividends. No pun intended here with the current dividend announcement which I'll talk about later. While we are pleased with the results of the proactive approach, we intend to remain vigilant and measured in our cost structure given the trends and our backlog.
From a revenue perspective, third quarter net sales were up $34 million or nearly 40% from the prior year. A majority of the sales increase was due to the addition of the service and delivery market that we strategically acquired to intentionally differ the fire portfolio.
Although even excluding the service and delivery segment, sales were still up approximately 8%. Motorhome and advanced vehicles contributed to the increase by $10 million and $7 million respectively.
As sequential basis, compared to the second quarter, sales were up almost $5 million or 4%. Sales in the specialty vehicle segment were fairly flat from last quarter reflecting approximately $7 million increase from the aftermarket parts and assembly business, offset by decreases in emergency-response.
However the delivery and service vehicles, a market that responds early to economic changes, posted a sequential increase of $5 million or 23% which bodes well for their future.
Our consolidated backlog was approximately $173 million as of September 30 compared with approximately $145 million a year earlier. The backlog for 2009 did not include Utilimaster. Excluding Utilimaster, our backlog was down slightly to $134 million or 8% for the prior year.
The decrease year-over-year was driven by declines in fire truck bodies and fire truck chassis as a result of the pull ahead of orders received in 2009, before the 2010 emission's requirements. These were partially offset by Motorhome and aftermarket parts orders which were up year-over-year.
Sequentially, our consolidated backlog has eroded as emergency-response market experiences a cyclical weakening in response of the tightening municipal budgets and also the spike in orders we received to 2009 for the engine emissions change.
Motorhome was flat compared to the second quarter, while service and delivery and aftermarket parts were down sequentially. Gross margin in the quarter was 16.4% down from 18.8% last year due mainly to a shift in product mix from defense and APA to Motorhome and delivery and service vehicles.
Low gross margins will be here for a while due to our current sales mix. However, we remain committed to improve our margins in each of the end-markets we serve.
Operating expenses increased by approximately $20 million in third quarter of 2010 compared to the same quarter of 2009, driven by the R&D expenditures that John talked about for the NGCV and the redesign of the Cab and Chassis for the 2010 emissions change.
The R&D cost included $1 million dollars related the NGCV and that design change cost in the 2010 emissions. R&D costs are elevated as we incurred the expense of prototyping and testing of these new products. We expect those costs to decapitate in 2011 with the conclusion of these programs.
Operating expenses in the prior year did not include the incremental spending from the acquisition of Utilimaster which was approximately $4 million in the third quarter 2010 excluding restructuring charges incurred in 2009 and the expenses related to the recently acquired Utilimaster, our operating expenses in the quarter were actually reduced by $2.3 million or nearly 18% compared to same period in the prior year.
Sequentially, operating expenses decreased by $2 million or 12%. Even more telling is the reduction in operating expenses as a percentage of sales as John mentioned earlier, from 15.8% in the third quarter of last year to 11.9% in the current quarter.
Sequentially, the percentage was down 230 basis points from 14.2% in the second quarter, all reflecting the momentum of our cost curtailment efforts. Keep in mind that some of the savings experienced in the quarter are one time savings such as the impacts from furloughs taken and temporary salary reductions.
The increased sales, improved margins and effective cost management have driven a positive operating income result of $5.4 million for the quarter which is up 105% from $2.69 million in the same quarter of 2009. As shared in the last earnings call, we also achieved our goal of mid single digit operating income as a percentage of sales which was 4.5% for third quarter of 2010.
We're also proud to report net earnings from continuing operations of $3.5 million or $0.11 per diluted share. Other major accomplishments come from the balance sheet with significantly reduced working capital resulting in a $28.8 million operating cash flow in first nine months of 2010.
Inventories improved with a reduction of $17.9 million since December of 2009 representing also a reduction of 17 days in inventory. Cost receivables were slightly up to the timing of some shipments of Utilimaster while we made great progress in reducing our working capital requirements. We see even more opportunity to improve, and particularly in inventory, where we could see additional gains in the near future.
A solid cash flow enable us to continue paying down debt in the quarter. Our debt balance totaled $15 million in September 30, down from $46 million at the end of 2009, and even down from the $20 million we had at the end of the second quarter.
Depreciation for the quarter was $2.6 million. Capital expenditures for the first nine months of 2010 were $3 million and we continue to forecast CapEx spending in the range of $4 to 5 million in 2010. With our strong financial position and positive long-term outlook, the board has approved management's recommendation to pay at semi-annual dividend for the second half of 2010.
A $0.5 per share dividend was declared for payment on December 09, 2010, for shareholder's record in November 11, 2010. In addition, the company's board also reauthorized management to repurchase up to a million shares of common stock over the next year. Both of these items reflect the strength of our balance sheet and our confidence in Spartan's future.
We are pleased with the quarter's financial results, (inaudible) past regarded where we are headed as a company. The business model where we can maintain solid gross margins and operating income, despite volatile demand are also strengthening our balance sheet along the way.
I'll now turn the call back to John to share some closing thoughts and our outlook as we finish 2010.
The third quarter was another quarter of implementation as we completed the exit of Road Rescue and continued our business realignment of driving improved financial result. You know the interesting thing is if you look at 2009-2010 we've not only been profitable in some of the most difficult time periods since the great depression, we've diversified our business significantly.
We have a major alliance with Isuzu which we never had before. We generated cash paying down debt relative to the acquisition. We've kept our dividend in place we've just announced, as Joe mentioned, a stock buyback which you're seeing in a company which is just following a pretty simple basic methodology, compelling products, growth in profitable market share, constant balance sheet management.
We just do those each and every day, all of us working together as a team, and it doesn't mean that everything in the future is going to be easy, but we have made significant progress as we transform this company from an opportunistic enterprise to one that is strategically and operationally focused as we look to the future.
And that goes well for all the stakeholders because there are significant challenges not just within the U.S. but within the world as well that are providing a lot of headwins. As I mentioned a few moments ago, the strength of our balance sheet demonstrated by the low debt, the sizable unused credit facilities to reduction levels of inventory complemented by strong cash generation, I mean that is a significant positive.
We look at the effective cost management, the focus on operations, short-term results, not just driven profitability, but also helps in long-term sustainability. We've resized our organization structure, tailoring to be more flex oriented within each one of our existing markets.
Cost management complimented by our strong balance sheet will not only position us for today, but will also position us for tomorrow as we look at new markets but also on the M&A satellites. We will be wise in all that we do, but the integration of Utilimaster is going on extremely well much better than the last M&A's which we started in 1997, and a lot of that's because of Joe Nowicki, Tom Gorman, a variety of individuals within Utilimaster and the Spartan teams, etcetera. were a group of people that are thinking and acting first from a wise perspective then executing together as a team.
As we look at our expanded market diversification, limiting our exposure to volatility in a single or narrowly defined market, we are in five markets today, most averaging about 20% of our salesmen. In essence, we have good diversification.
When we look at growth in the future, where will it come from really? Four areas: organic, internal innovation, alliance, similar to what's going on with Isuzu, acquisition as replicated or demonstrated by Utilimaster, and aftermarket parts and assemblies. Bottomline, we are a significantly different organization but stronger from a long-term shareholder value perspective than what we were three years ago.
Quickly, as we look at the catalyst within each market, I talked about the 2010 emissions, the improvements in the Cab. We look to Crimson Fire relative to the transform of the Legend, the First Response All Calls vehicle, and what's important I think for the group to know is that Crimson Fire brand is really our fairly new brand.
It's really been in existence less than six years. Prior to that, it was quality in the burn, just some recent deliveries, Chicago, Dallas, Toronto, Buffalo, San Francisco. So when people ask me why am I excited about Crimson Fire? Well, first is indeed call for help every 1.25 seconds, second, it's a new brand.
Third, operationally, they've done a lot to improve gross margins, reduce operating expenses. Fourth, they moved into a new facility on the aerial side of life in Africa, Pennsylvania, which will not only reduce the cost of building an aerial provided some opportunity relative to reimbursement, but also will enable us to enhance the compellingness of the product if we produce it from a leaner perspective.
Talk about the NGCV as it relates to delivering the service, I think something which is quick to know how we have changed dramatically over the last 12 to 18 months. When we look at innovation today, relative to compelling products, lean is inherent within the innovation philosophy. It was not three years ago, five years ago.
Which means when we bring an innovative product to market, we are also very focused on lean, what's going on from a bill of materials, a profit perspective so that when we bring a product, so that when we bring a product to market, it is compelling, it is also lower in cost to produce and easier to service when it goes into the field.
What's nice is when I look at the Spartan Chassis, the new 2010 Cab and Chassis design, Crimson Fire's Transformer, the Legend and its First Response All Calls vehicle, the FRAC. When I look at Utilimaster's NGCV, these are the first products reflecting this new thought process methodology.
As time goes on, that number will grow. But that's why you're also seeing some of the improvements in the margins. The Isuzu alliance and assembly agreement will leverage our capacity, provide us some opportunity, create jobs, but again, we know touch 47 out of 58 markets.
If you look at the defense business, it's very, very challenging but also the opportunity will grow for small wins, but we still have to execute. We've got some great data metrics in each one of our markets, call for help every 1.25 seconds. What is interesting is over 100,000 kidnappings a year, over 300 IEDs per month outside of Afghanistan. We've got an installed user vehicle base in North America, of 225,000 vehicles, 11,000 people a day turn 50, which is good for recreational vehicles but also for emergency-response.
When you look at the price per barrel of oil, up over 224% since 2000, and this is key as people start to look at the next generation commercial vehicle because the improvement in fuel economy is significant though we're very focused on green, reducing the carbon footprint, emerging markets taking advantage of global opportunities. We shipped 22 trucks to Beijing, where they will become fire trucks for Beijing this past quarter, another first for Spartan Chassis.
And again, less than 3% of our sales are export and we've got significant opportunity. The currency puts us in a great opportunity both from an alliance perspective and an expert perspective. It's challenging and while I've just talked about a lot of positives, again we remain very guarded in our near-term outlook in many of markets.
And the reality is, there is tremendous global and North American uncertainty. We do have tightening municipal budgets. We have increased environmental and regulatory issues. But while we are happy with headwinds in front of us, in challenges, our focus is sound and it's simple, compelling products, growth and profitable market share strengthen the balance sheet in the appropriate construction.
We got challenges; very, very cautious. I want to thank (Golby Associates) for their efforts and accomplishments this past quarter. Now it's time for questions.
(Operator Instructions) Our first question comes from Joe Maxa from Dougherty & Company.
Joe Maxa - Dougherty & Company
I appreciate the outlook and the color on the OpEx and trying to right-size the business. A couple of questions. How much more should we be thinking about taking out of the model, as well as let's take a look at the backlog being down sequentially. And given your cautious comments, should we be looking for backlog to decline a similar amount in the next quarter?
I'll take the first one on the cost reduction part and then I'll hand over the backlog piece to John to talk about. I think we made a whole lot of progress in really realigning the cost structure across the companies. You've heard him say, as we like this on the numbers, just phenomenal efforts by all of the teams.
We're a different sized company than before and we need to align the cost structure, get into this mid single digit operating income, kind of the goal and target we had in mind. That's the answer to your question. It'll be round about right so far, but to answer your question, there are no other significant changes that will be taking place in this platform given the current revenue stream where we're at.
Are we always looking at other ways to improve our operations? John talked about lean and big initiatives we are going on and will that help us to improve our margins with all our cost structure? Absolutely.
I think we've done a lot of heavy lifting and gotten most of that cost structure that we needed to resize ourself already gotten in place. Now, on the backlog question.
I appreciate your directness because you're getting to the need of the issues or the opportunities very, very quickly. As we look at 2011, we do expect the topline to be done slightly. And let me just first give you the ups and the challenges as we look at each market.
Recreation, especially vehicle, we would anticipate to be up slightly, delivery and service to be up. The alliance with Isuzu will also drive growth. When we look at the challenges, we have the emergency-response market that should be down some. The defense market should be down some.
In aftermarket parts and assemblies, the defense portion should be down some. On the ER delivery and service and recreational, especially vehicle side, that should be up. But when you add it all up, we probably should be down slightly some in 2011 from a top-line perspective versus 2010.
Joe Maxa - Dougherty & Company
And I would assume you would look at the first half being weaker than the second half with Isuzu coming on the in the back-half, another product.
We got a little carried over in the first half of the year. The emergency-response business and also the defense business and some of those programs still continued out a little bit into the first quarter. So I think what you'll see is, in each of those markets a little different reaction, right?
The emergency-response business probably will tail off more in the second half of the year. And even though we will pick up some of the work thrown as usual in the second half of the year which should help to offset that. Keep in mind, there is a ramp up during that second half of the year as well too.
We won't start right up with the full high in this, but the new next-generation commercial van it's pretty limited volume yet next year second half of the year. Leads are slowing down a little bit towards the second half of the year as well too. And then may be towards the end of the second year, you'll see some of those improvements as you mentioned from Isuzu.
I think as Joe mentioned, probably, where you see the greatest opportunity or the topline movement in the up direction is probably in Q4 going into 2012 just because that's where you'll start to see this next generation commercial van really come to marketplace in some significantly large volumes.
And I mentioned earlier, you want to be very conscious in the ramp up, because you've got an education of the workforce, profits, developments, etcetera. But you want to make sure each and every vehicle going to the marketplace is absolutely correct from a performance perspective.
Joe Maxa - Dougherty & Company
The last piece I'll add on to is, I'll close by circling back to the cost reduction question please. Hopefully what we've been able to demonstrate is our ability to flex the business with a revenue stream that comes across, right? Our attempt is the try to get to a more variable cost structure and also manage the balance sheet. So regardless of what happens with the volumes, you will see us to continue on that philosophy as we go forward.
I think what Joe was saying is that, we will never lose our focus on improving our cost structure or our balance sheet management. This process of continuously improving to more flexible cost structure perspective is something which is becoming really a daily part of our life.
Joe Maxa - Dougherty & Company
Question on the gross margin. I mean certainly they will vary the business mix and what not, but how are commodity prices impacting you currently? And what are your thoughts on the commodities going forward?
That's something that we watch and pay attention to daily. Actually to this point, all the commodity prices have been reasonably stable. We haven't seen a significant impact one way or another on the commodities. Also, the one advantage we have is we can price some of that into our product as well too which we do get in the lead times with that.
Our next question comes from Ned Borland from Hudson Securities.
Ned Borland - Hudson Securities
If we're looking at margins, if you've done all this work on the cost structure and you're expecting the topline to decline slightly next year, I mean, are we looking at kind of a higher level of steady-state operating margins going forward? I mean are we looking at, say, instead of being kind of 1% operating margins, are we looking at maybe like 3%, 3.5% if volume declines from here?
Are you referring Joe to the operating income, or are you talking about operating margins?
Ned Borland - Hudson Securities
What we've described kind of long-term going forward is this mid single digit operating income number. That goal hasn't changed. We haven't wavered from it at all. I think as John was talking about, we'll have some, I think a short-term, because of some of the backlogs that we have for the defense vehicles and also the fire trucks, fine in the short term.
But long term, we're committed to that mid-single digit operating income without question. In the mid-term, is a part where, which the volumes and some of those declines, it will be a more (technical difficulty). But we'll continue to focus. I'm trying to literally manage that cost structure to get to that spot. It's going to be hard in that mid-term range though.
Ned Borland - Hudson Securities
By mid-term, you mean between now and sort of the second half of next year, when you have the new van in place, right?
Ned Borland - Hudson Securities
And sort of segwaying to that, what are the sort of margin assumptions on the new product versus the legacy product of Utilimaster? I mean, is there a significant increase in margin on that, on a unit level?
Yes. I think, how I would address it is, it's definitely an improved margin from the current one from a couple of regards, it's obviously the next step up in the product in terms of capabilities, fuel efficiencies and economics to it, so also design for manufacturing in a much better way than the old product was as well too.
And also the old product has gotten to be a little bit more of a commodity product there, whereas it's very price competitive on it. So we'll see a little bit improved margins, yes. I mean new products versus the old definitely.
Ned Borland - Hudson Securities
And then, just sort of on the near-term outlook for Utilimaster, I mean, are you sort of forecasting kind of in the first half, you'll have a lot of your customers sort of waiting back for their new product or are there any kind of timing issues with regard to the launch and how are your customers are (inaudible)?
The good news is, the delivery and service business, actually the request for product holding even on the current product continues to improve each quarter. I think we're just starting to see some of the improvements as noted by the trucking companies, the train carriers etcetera.
The economy is slowly moving in the right direction. So I think it's still good to see demand for the current step van and truck body product. I will say this in the current product, the pricing is probably more challenging and more competitive than what it was 2 years ago. But now, as we look at Utilimaster and delivery service in Q1 and Q2, we do expect the ball to move in the right direction and for them to continue their improvements.
The next-generation commercial van will be an accelerator, but it's really not going to get a kick in the high gear while it will start in Q3, it's not really going to kick into high volume gear until late 2011 Q4 and 2012.
Ned Borland - Hudson Securities
So you would not view the next generation van cannibalizing some of Utilimaster's legacy products?
Long-term, yes, short-term over the next, I would say 12 to 18 months, no.
And I think also the matter of degree. Certainly not cannibalized some of the existing product sales of the old style commercial vans that they utilized, but not all. But there still will be a need and customer base that requires the size and capacity of the old style truck.
I mean, one of those things, I'm not sure we mentioned this in the past, and if the next-generation commercial van can carry about 12,000 pounds where a large number of Utilimaster products clearly not carry just not just 12,000 pounds, but they carry 14,000, 16,000, 18,000, 20,000 pounds.
As Joe mentioned earlier, there is a variety of people in delivery and service that either need it in huge capacity, for example, like a Frito-Lay where they just need a lot of space, or you got people that need a lot of weight, for example, loads in the clothing etcetera or the tool part of life.
So there will be some cannibalization, not very much short-term, will be a little bit more long-term, but the large (GVW), a large cube capacity, not that market is still going to be there.
(Operator Instructions) Our next question comes from Mike Ruggirello from Barrington Research.
Mike Ruggirello - Barrington Research
So, we saw some good improvement in the SG&A this quarter sequentially. And I guess I wanted to wonder how should we look at that going forward as a percentage of sales?
On the SG&A side, as we talked about, we continue to have lot of efforts in improving the operating expense as part of our equation. And the volume helped this quarter as the percentage of sales to help it decline. But even as the dollars we made great strides in improving the dollars too.
When you take out the Utilimaster acquisition or incremental cost and try to get to the same store, operating expense numbers, they are down about 20% from year-over-year where they were at, so we've really gotten that to the right level where we wanted to. Long-term growth an operating expenses is as we've talked about, getting into that 11% range.
Because our goals, as we've talked about, mid single digits on the operating income, trying to getting us to the gross margins in that seventeenish range and operating expenses in that 11% to 12% range. And what was there at that point right now and I'm feeling good about operating expenses structure at this level of volumes definitely.
Mike Ruggirello - Barrington Research
We saw a nice bump-up in Utilimaster sales this quarter. Should we think about that as a good run rate going forward, or how should we look at that sequential improvement in Utilimaster sales?
Yes, you are right. You saw a nice increase in the volume and that also helped to, as you saw, in the bottom line, drive some profitability as well too. We've talked about with them that $100 million (pricing). So then gets them to their break-even point and when they crossover like they did this quarter, it turns them into profits which is good, even with the additional funding they are doing for the next generation commercial vans (inaudible).
I think based on their backlog and what we've seen in the order rates, that pacing seems like it is going to be here for long.
Mike Ruggirello - Barrington Research
A question on the RVs, is it still mostly just dealers or are we seeing some consumer pull-through? I know you mentioned that consumer confidence is a good indicator. I was just wondering what specifically you guys are seeing?
I would say it's dramatically, or by far, the majority consumer pull-through. And you are not just seeing it in our views, I mean there is a number of articles and postings, whether it be cars, purses, clothing etcetera., that while the market finds it smaller, the luxury good part of the marketplace is definitely rebounded.
One dealer I think said it best to me. He said, "John, the high end of the Motorhome marketplace, the large end of the Motorhome marketplace is definitely smaller. But the fact is that the financial markets have stabilized and actually gone up some, that the people who have the wealth now feel more comfortable about the future because there is stability. So they are buying."
That methodology applies whether it be a luxury Motorhome, luxury car, anything that's defined within the luxury, the markets are smaller and nobody is arguing that, but those people within that market feel more comfortable about the future primarily because they see stability in the financial market. So they already have the wealth, they just want stability.
So they have wealth, they see stability; they are going out to buy, which is good. We would just like to see more of them.
Mike Ruggirello - Barrington Research
And I guess, finally, my question is just in the capital structure, what's your plan on that? Obviously, you guys paid down a lot of debt. What are you looking for going forward?
If look at our capital structure back, we just had a great review with the board last week, talking to some tenants around capital structure and where we're headed. Call it the next big item, two items as a part of our capital structure tenants you saw that we talked about today, one was the dividend.
We continue to believe that dividends are providing a great return for the investors. So we plan to continue down that dividend track as we have. Second is around the authorizations to repurchase a stock. You will us continue to make some strides to buyback some stock as well too. We do believe that our attempt is to minimize any of the impacted dilution that you get from any of the benefit programs.
So the board authorizes the million share stock repurchase. So that's the second vehicle that was in this.
Third, if you look at the debt elements of our balance sheet, we have about $15 million in debt remaining out there. $10 million of it comes due next month. So that will be coming due during this quarter. Given the high cash balance that we have currently, and our ability to continue to generate cash as we've seen in the last few quarters, it's probably expected to pay it off and pay off that debt and get out of it altogether.
So I would expect that we will be ending the year with about $5 million debt balance out there. That gives you a sense of where we are going, Mike?
Mike Ruggirello - Barrington Research
Absolutely, that was just what I was looking for and that's all my questions.
And I would just like to make a comment about the debt reduction. And all of you can figure this out yourself form a math perspective when you start to get into the Q, etcetera. But year-over-year, our inventory days outstanding was reduced by 30%, and when we look at our cash conversion cycle, that number was improved or reduced by 38%.
Part of what you are seeing, which you didn't see three, four or five years ago, is it's a very disciplined thought process to compelling products, growth in profitable market share, cost management and balance sheet management, which is one of the reasons why, since being with the company in 1985, do we have significant challenges?
Absolutely. But I have never seen more opportunity, but as stronger financially to take advantage then in the 25-plus years that I've been in the specialty vehicle business.
At this time I am showing no additional questions. I would like to turn the conference back over the management for any closing remarks.
I sort of made a closing remark just a few moments ago. But really, for a shareholder perspective and stakeholder perspective, I do want to thank the shareholders for your interest, but also your support. It's amazing what we've learned by interacting with very, very wise people.
Second, all of our stakeholders, suppliers, dealers, OEMs, our associates, the communities which we serve in, want to thank them for their partnership and support. We had a very solid quarter. As I noted in my board report, this is a glimpse as to some of the performance metrics we can demonstrate now. As a company we've got three great brands, we've got markets with challenges all with opportunities.
The good news is, we are positioned very, very sound financially which gives us the opportunity, whether it be a stock buyback, whether it be an alliance, whether it be an acquisition, an innovation. I think we've got very good methodologies to make the right decisions. And last, just want to complement the board for their wisdom, their support.
So in closing, we've got a lot of work to do. We've got some severe challenges, significant challenges, but we also have a great opportunity and after this call, we just get back to the work. Thank you very much.
We thank you for attending today's conference call that has now concluded. You may now disconnect your telephone lines.
Copyright policy: All transcripts on this site are the copyright of Seeking Alpha. However, we view them as an important resource for bloggers and journalists, and are excited to contribute to the democratization of financial information on the Internet. (Until now investors have had to pay thousands of dollars in subscription fees for transcripts.) So our reproduction policy is as follows: You may quote up to 400 words of any transcript on the condition that you attribute the transcript to Seeking Alpha and either link to the original transcript or to www.SeekingAlpha.com. All other use is prohibited.
THE INFORMATION CONTAINED HERE IS A TEXTUAL REPRESENTATION OF THE APPLICABLE COMPANY'S CONFERENCE CALL, CONFERENCE PRESENTATION OR OTHER AUDIO PRESENTATION, AND WHILE EFFORTS ARE MADE TO PROVIDE AN ACCURATE TRANSCRIPTION, THERE MAY BE MATERIAL ERRORS, OMISSIONS, OR INACCURACIES IN THE REPORTING OF THE SUBSTANCE OF THE AUDIO PRESENTATIONS. IN NO WAY DOES SEEKING ALPHA ASSUME ANY RESPONSIBILITY FOR ANY INVESTMENT OR OTHER DECISIONS MADE BASED UPON THE INFORMATION PROVIDED ON THIS WEB SITE OR IN ANY TRANSCRIPT. USERS ARE ADVISED TO REVIEW THE APPLICABLE COMPANY'S AUDIO PRESENTATION ITSELF AND THE APPLICABLE COMPANY'S SEC FILINGS BEFORE MAKING ANY INVESTMENT OR OTHER DECISIONS.
If you have any additional questions about our online transcripts, please contact us at: email@example.com. Thank you!